Diesel Fueling Vent Frustrations - Pun Intended

B

BOSCBIJI

Well-known member
Joined
Aug 11, 2025
Messages
54
Fluid Motion Model
Ranger Tugs Models
Howdy folks -

Curious to hear from Diesel boat owners, particularly recent model 29's and 31's...I CANNOT seem to fill my tank without fuel coming through the vent. Its not a lot, but its near as I can tell impossible to avoid.

Happens with the pump running slow, running fast, running slow then fast, running fast then slow. Happens at the beginning of fueling, midway and at the end. Cold weather, hot weather, no additive, additive...nothing seems to make a difference.

Maybe we have a vent line problem from the factory? We have no other fuel issues and the vent seems to otherwise function correctly.

Doesn't seem like anything I can do keeps the fuel from gurgling at least a dribble out the vent. Which while manageable, its getting pretty old holding an absorbent pad under the vent while I try to pump at the same time.

Thanks in advance!
 
I have a 2017 R29 sedan and have experienced the same situation when fueling. I found that positioning the fuel nozzle certain ways and speed of delivery helps but does not eliminate some fuel coming out the vent. I can’t give you specifics as it varies with the fuel nozzles used.

Mike
 
Ours only happens at the end of the fill.
 
This issue has literally been discussed for at least a decade. There are several commercial devices to address the issue.
1. Inline Vent Line Surge Protectors like the Attwood Fuel Vent Line Surge Protector.
2. Fuel whistle alarms like the Scully Vent Pipe Fill Signal or the Green Marine Fuel Whistle for smaller marine hoses.
3. Deck-Fill Overfill Preventers which are portable or retrofittable devices that plug directly into the deck fill pipe.
4. Just don’t fill your tank to full. We fill ours to 90%. Only once in every 4-5 fills to we go past 90% and then we use a whistle alarm. The fuel level read out at the Garmin is pretty accurate for fills between that.
 
I took my fuel float out of tank to check it. There is two inches of air space left when float is maxed out. I have no idea how many gallons are in the 145 gallon tank when Garmin reads 100%. I was told by a Ranger Tug whiz that I should fill past 100% and stop when I hear the magic gurgle. Forget all that. The game changed when I got a "fuel catch" brand bottle. Or another brand is "no-spill". $45 on Amazon, and sometimes half that on eBay. I read how many gallons are left on Garmin, subtract that from 145 gal. Pump fast until near that and slow down until a little fuel flows into bottle. Bottle fits vent with two function cups. Add run-away string to bottle unless you want to pay another $45. Most expensive plastic bottle around yet worth it.
 
I fill to 15L underfill or "magic gurgle", whichever comes first. Occasionally I get inexplicable fuel mist coming out of the vent before approaching full; unusually foamy fuel for some reason? (Collapsing foam known to generate aerosolized mists).
/diatom
 
There are two fuel tanks on the R43, the aft one spits out quite a bit from the vent but the forward tank dribbles not at all. I think the forward tank has a longer distance from the tank to the vent and that might be the reason. Anyway, as Mastercraft mentioned, using a vent minder is what I do also. The suction cups stick better if you wet them first and also rub the salt off the hull before attaching.

1779716026913.png


In addition, I use this device that is designed to capture overflow, but in fact we never get to that point. The real advantage of this is that it amplifies the sound of the fluid in the pipe and I find it much easier to detect the change in pitch when I get to the full tank level.

1779716245181.png
 
I was at the fuel dock the other day...put in 80 gallons of diesel fuel. Of course, I got a dribble from the vent occasionally and I was concerned about it until the fuel attendant says "We don't worry about it unless it's 20 gallons or so." 😀
 
scross said:
This issue has literally been discussed for at least a decade. There are several commercial devices to address the issue.
1. Inline Vent Line Surge Protectors like the Attwood Fuel Vent Line Surge Protector.
2. Fuel whistle alarms like the Scully Vent Pipe Fill Signal or the Green Marine Fuel Whistle for smaller marine hoses.
3. Deck-Fill Overfill Preventers which are portable or retrofittable devices that plug directly into the deck fill pipe.
4. Just don’t fill your tank to full. We fill ours to 90%. Only once in every 4-5 fills to we go past 90% and then we use a whistle alarm. The fuel level read out at the Garmin is pretty accurate for fills between that.
Click to expand...
It’s not a full tank issue.

Fuel vents at any and every point in fueling from low, mid, high. In fact if anything, there seems to less fuel venting in the final 30 gallons.

We leave a 5 gallon buffer so as not to overflow the vent or top.

Seems like the capture devices make the most sense.
 
You must log in or register to reply here.

  • Tugnuts.com is the community hub for Ranger Tug, Cutwater, and Solara owners. Since its inception in 2008, the Tugnuts forum has grown into an active and thriving community of more than 9,000 members. It serves as both a meeting place for the best boating community online, and an invaluable archive of information.

  • User menu
Back
Top